Search results

  1. S

    Question too much oil on dip stick

    Yes the 6.4 does have issues with fuel injectors leaking into the crankcase. I Have seen many at work. I changed the oil on it and about 15 quarts came out!. Not a good thing. As far as changing your oil every 10k. I dont care what the manual says. I would do it 5000 to 7500. Its just to big of...
  2. S

    Fluidampr pulley

    Has anybody out there ever install a fluidamp crank pulley? And did they notice any gaines from it? I have a buddy that swears by it. Just wondering if it really is worth it sins they are expensive.
  3. S

    Question Is there additional oil to change?

    There is no such thing as injector oil! Crank case oil is circulated though the injectors. The injerctors run off of high pressure oil fed bye the low pressur oil system. And yes when you do an oil change not all of the oil is draned out of the engine. about 2-3 quarts is still in the high...
  4. S

    ReFlash

    Any dealers service department should be able to tell you. They just have to run oaises and it will tell you if there is any open recalls for your truck
  5. S

    Headstuds - cab on or off?

    personaly I have never done head studs on a 7.3. Have done many on 6.0 and on all the cab came off! If it was me i would pull the engine if you have the equipment.
  6. S

    Safety Belt Light Help!!!!

    I would look under the driver seat to inspect the wires/connectors for chafing or not connected, if the look ok Its most likely the seat belt buckle.
  7. S

    New wiring harness for 6.0

    The fuel injector harness is pretty easy to do. take about an hour if you never done one.
  8. S

    2005 SD 6.0 surges

    sounds like a turbo issue. pretty common on 6.0. What happens is rust builds up on the turbine side where the vains slide. it causes them to kinda jump
  9. S

    2001 Diesel 4wd. quit.

    [ What is the cruise recall for? Does it make the cruise work better The recall is an inspection of the cruise control switch on the master cylinder and a fused jumper harness. If you send me the vin number i can check if you have any open recalls.
  10. S

    New wiring harness for 6.0

    Yes i have replaced many fuel injector harnesses for running rough and miss fire concerns. As a matter of fact i got one in my bay right now!
  11. S

    Power Steering

    Not all 2011 6.7 diesel have hydro-boost vacuum brake booster is available for both gasoline and diesel engine vehicles. The vacuum power brake actuation system consists of the following components: Brake booster assembly Brake booster check valve Vacuum hoses Brake vacuum pump...
  12. S

    serious electrical problem

    A parasitic draw is an unwarrented power draw from the batteies when the truck is shut off. If you have a multi meter i would hook it up yo one of the batteries. keep the key off and start pulling fuses one at a time. when you see the reading change on the meter thats the fuse/circuit thats the...
  13. S

    Interior dome lights not working

    Sounds like a GEM to me! its an easy repair. just remove the radio and you can stick you meat claws back there
  14. S

    Door Ajar Light

    sound like a GEM module to me!!!!
  15. S

    Gauge kits

    maxboost for a 7.3 is about 25 30psi
  16. S

    new member

    OK well in that case i would check the resistance from each glow plug wire haness. if not sue how to. find the glow plug harness connector. one on each side of the engine. unplug the connectors. put the multi meter on ohms. put one lead on battery negative and the other lead on each pin in the...
  17. S

    new member

    Could be a Few things. could be you glow plug module, glow plug wire harness/bus bar. or a few glow plugs are dead. they are kinda a pain to do if you never done them before. let me ask you! do you have a muli meter?
  18. S

    glow plug relay trouble

    well you may not need a module? You may need a few glow plugs. Do you have a multi meter?
  19. S

    glow plug relay trouble

    Hey stinger 438! the 2004 6.0 do not have a glow plug relay on the fire wall. the 6.0 uses just the glow plug modul powered though the engine junction fuse box. Why do you ask? is the truck hard starting in cold?
  20. S

    Power Steering Box

    Pull the left inner fender well out. You can get to them really easy
  21. S

    Help Needed windsheild washer pump fuse

    I believe its fuse 33 15A in the central junction box
  22. S

    New engine oil change intervals?

    I've done an engine on a 2007 township truck (17000 6.8 V10) never changed there oil and you would not believe how bad that engine was gummed up!....They payed for that one!!!!
  23. S

    03 6.0 no start

    the tsb is for 2005-07 6.0. they have a stc fitting on the back 0f the hpop that blows apart. On the 03-04 6.0 they have a different hpop! just thought i would tell ya!
  24. S

    03 6.0 no start

    Tho 03 6.0 are not very common for a crank no start i have seen a few different things....The most common is the ipr valve. It sounds like you have a high pressure oil leak tho. The most common on a 03 6.0 is an injector leaking. this may not even give you a drivability concern. i would get...
  25. S

    Help Needed releasing cruise control

    Possible its your brake switch. Try pressing on the brake a little bit and seeing if your brake lights turn on.

Members online

No members online now.
Total: 138 (members: 0, guests: 138)

Forum statistics

Threads
30,516
Messages
266,069
Members
14,628
Latest member
Svttim

Latest posts

Top